|
|
||||||||
Ann Thorac Surg 1996;62:1724-1730
© 1996 The Society of Thoracic Surgeons
Section of Cardiothoracic Surgery, UMDNJ-New Jersey Medical School, Departments of Surgery and Preventive Medicine and Community Health, Newark, New Jersey
| Abstract |
|---|
|
|
|---|
Methods. Glutaraldehyde- and No-React-pretreated porcine aortic valve cusps were implanted subcutaneously in 6-week-old rats (n = 20). At 3, 6, and 14 weeks, randomly selected animals were sacrificed and the explants underwent mineral and morphologic analyses. Glutaraldehyde- and No-React-treated bovine pericardium and porcine aortic valve cusp were incubated in fibroblast cell culture plates. Cell viability was observed under reversed microscope at 6, 24, 48, and 96 hours. Erythrosin B dye exclusion test was used to validate percent cell death.
Results. Pretreatment with No-React significantly inhibited calcification of aortic cusp subcutaneous implants throughout the 14-week period (mean tissue Ca2+ content = 1.3 ± 0.7 µg/mg at 14 weeks.) Glutaraldehyde-treated cusps underwent protracted calcification (Ca2+ content = 190.6 ± 89.5 µg/mg; p < 0.01). Morphologic findings correlated with mineral analyses. One-hundred percent of fibroblast cells survived in the presence of No-React-treated tissue, with a growth pattern indistinguishable from control cell culture (ie, in the presence of no tissue). The cells incubated with glutaraldehyde-treated tissue showed signs of nonviability by 6 hours, with 100% cell death by 48 hours. Dye exclusion tests validated these findings.
Conclusions. The No-React detoxification process completely abolishes the cytotoxicity of the xenograft tissue and inhibits calcific degeneration.
| Introduction |
|---|
|
|
|---|
The search for a durable bioprosthetic heart valve has been a focus of intense investigation for the past two decades. Biological valve prostheses display superior hemodynamics and low thrombogenicity [1]. The relative simplicity of insertion and reported reduced incidence of thromboembolism are among the other advantages of the biological valve prosthesis over mechanical valves [1]. However, the major factor limiting clinical use of the commercially available glutaraldehyde (GTA)-pretreated bioprosthetic valves is their late structural deterioration, most commonly as a result of calcific mineralization and degeneration. Reoperation, and its associated morbidity and mortality, is the eventual outcome in approximately 20% to 30% of the bioprosthetic valve recipients by the tenth postoperative year [1, 2]. Moreover, several retrospective clinical reports have described accelerated tissue valve calcification and earlier functional failure in young adults and children, condemning biological valve implantation in these groups of patients [35]. Glutaraldehyde is currently the standard reagent for preservation and biochemical fixation of fresh bioprosthetics of either bovine pericardium or porcine aortic valve cusp origin. Multiple studies have implicated the aldehyde-induced collagen cross-linkages and devitalization of the intrinsic connective tissue cells of the bioprosthetic valves in initiating tissue mineralization [2, 68]. The cytotoxicity of GTA has been detected in animal tissues as long as 6 months after implantation [9]. Furthermore, alarmingly, GTA has been traced in human porcine valve explants up to 14 years after implantation [10].
Since the introduction of the No-React (NR) biochemical modification method by Biocor, Belo Horizonte, Brazil, our laboratory has engaged in delineating the merits of this aldehyde detoxification process in preventing xenograft dystrophic calcification. Previous studies in our laboratory have demonstrated comparable in vitro tensile strength of the NR-processed heart valve bioprostheses [11, 12]. Moreover, we have described antiinflammatory and anticalcification properties of the NR on bovine pericardial subcutaneous implants [13]. We have observed severe foreign body reaction in the form of giant cell infiltration in GTA-pretreated pericardial implants, a response completely abrogated by NR pretreatment. These findings were suggestive of a correlation between the inflammatory destruction of the tissue implant and the pericardial calcification. The present study illustrates our longitudinal observations on the trend of mineralization of subcutaneously implanted porcine aortic valve cusps pretreated with GTA versus NR. Furthermore, it examines the dichotomous results of extensive cytocompatibility testing of GTA-treated versus NR-treated xenografts, and investigates the potential correlation between xenograft tissue cytocompatibility and calcific mineralization.
| Material and Methods |
|---|
|
|
|---|
MINERAL ANALYSES.
Aortic cusp explants were washed with sterile saline solution and dried to constant weight in a 90°C desiccator oven. Tissue concentrations of calcium was determined by previously described techniques [14] using flame atomic absorption spectrophotometry (Perkin-Elmer model 603; Perkin-Elmer, Norwalk, CT) after digestion with a 3:1 mixture of 70% nitric and perchloric acids (GFS Chemicals, Columbus, OH). National Institutes of Standards and Technology bovine liver (SRM 1577a; Gaithersburg, MD) was used as a quality control sample for all analyses. Concentrations were expressed as micrograms per milligram of dry tissue weight (mean ± standard deviation).
MORPHOLOGIC ANALYSES.
Sample fragments removed for histologic evaluation were fixed immediately in 10% neutral buffered formalin, dehydrated in graded concentrations of ethanol, cleared in xylene, and embedded in paraffin according to standard methods. Sections 5 µm thick were stained by hematoxylin and eosin and von Kossa stain.
Cytocompatibility Studies
CELL CULTURE.
The cell line used was L-929 mouse fibroblast cell line obtained from the American Type Culture Collection (Rockville, MD). The cryovial of cells was immersed in oscillating 37°C water bath within 1 to 1.5 minutes. The cell suspension was then sterilely transferred to a 75-cm2 culture flask containing preequilibrated and prewarmed Dulbecco's modified Eagle medium (pH = 7.30), supplemented with penicillin (100 IU/mL), streptomycin (100 µg/mL), amphotericin B (2.5 µg/mL), fetal bovine serum (10%), and nonessential amino acids (1%) (BRL, Grand Island, NY). The culture flask was incubated in 37°C humidified incubator with 5% CO2 concentration in air. After 72 hours, the confluent cells were subcultured at approximately 40,000 cells/cm2 in 12-well dishes (Falcon, Becton Dickenson, NJ) and allowed to grow to a monolayer of cells before introduction of tissue samples.
CYTOCOMPATIBILITY TEST.
Glutaraldehyde- and NR-pretreated tissue segments were cut into 3 x 3-mm strips under sterile conditions. The strips were washed in three serial changes of sterile phosphate-buffered saline solution (pH = 7.3) and individually introduced into the cell culture wells. The wells were then supplemented with fresh medium. At 6, 24, 48, or 96 hours after incubation, the cells were examined under a reversed light microscope. One cell culture dish containing no tissue was assigned as a control in each set of experiments.
DYE EXCLUSION METHOD.
Six, 24, and 48 hours after tissue incubation, 0.5 mL of 0.06% erythrocin B solution was added to each cell culture well, dwelled for 30 seconds, and then withdrawn. The dyed cells immediately adjacent to the tissue were counted under bright-field reversed microscopy. The rationale for this technique is that viable cells are impermeable to dye (erythrosin B; Sigma, St. Louis, MO). On the other hand, the dye leaks into those cells that have sustained critical damage to their plasma membrane. The ratio of stained cells to total cells counted (x100) estimates the percent cell death. (Note: it is important to bear in mind that this method can overestimate viability, as other forms of cellular injury progressing to cell death are undetected.)
Statistical Methods
Tissue calcium content were compared for differences between GTA- and NR-pretreated tissues using two-tailed independent Student's t test. Percent cell viability (discontinuous data) were evaluated by
2 analysis using the Fisher exact test. Statistical significance was declared at p less than 0.05.
| Results |
|---|
|
|
|---|
|
|
|
|
|
|
|
| Comment |
|---|
|
|
|---|
No-React xenograft pretreatment involves (1) aldehyde cross-linkage to achieve high resistance to biodegradation, (2) an aldehyde detoxification process, and (3) surface modification with a surfactant. The results of the present study illustrate the superior biological properties of the NR biochemical modification process, the attributes that we believe are fundamental to formulation of an acceptable bioprosthetic tissue preparation method. These properties are as follows: (1) No-React pretreatment maintains intrinsic collagen architecture and structural integrity of both bovine pericardium and porcine aortic valve cusp in an in vivo environment. (2) No-React aldehyde detoxification process inhibits crystal enucleation on the xenograft tissue, in what we have observed as a near-complete abolishment of calcific mineralization of the implants to a degree indistinguishable from historical untreated tissue implants. (3) The remarkably inert nature of surfactant-protected NR-treated tissue supports coexistence and normal growth of connective tissue cells, illustrating optimal cytocompatibility. In other words, the NR biochemical modification process efficiently protects the components of the xenograft tissue that are subject to calcific deposition, namely collagen and connective tissue cells. We have also shown that conventional GTA is a clearly inferior tissue-preparative modality. Glutaraldehyde has toxic effects on both extracellular and cellular elements of bioprosthetic xenograft, inevitably leading to calcific degeneration.
Given these preclinical findings and the encouraging early results of the ongoing clinical investigations on the use of NR-treated biological implants [16, 17], we foresee the future era of the biological heart valve implantation to involve exclusive insertion of detoxified tissue valves with superior long-term durability in a wider spectrum of recipients.
|
| Footnotes |
|---|
|
|
|---|
Address reprint requests to Dr Gabbay, UMDNJ-New Jersey Medical School, 185 South Orange Ave, Rm G-502, Newark, NJ 07103.
| References |
|---|
|
|
|---|
-carboxyglutamic acid, and calcium in explanted bioprosthetic heart valves. In: Gabbay S, Frater RW, eds. New horizons and the future of heart valve bioprostheses. Austin, TX: Silent Partners, 1994:191--201.
Related Article
This article has been cited by other articles:
![]() |
T. P. Carrel, F. S. Schoenhoff, J. Schmidli, M. Stalder, F. S. Eckstein, and L. Englberger Deleterious outcome of No-React-treated stentless valved conduits after aortic root replacement: Why were Warnings ignored? J. Thorac. Cardiovasc. Surg., July 1, 2008; 136(1): 52 - 57. [Abstract] [Full Text] [PDF] |
||||
![]() |
P. Stelzer Stentless Aortic Valve Replacement: Porcine and Pericardial Card. Surg. Adult, January 1, 2008; 3(2008): 915 - 934. [Full Text] |
||||
![]() |
W.-H. Kim, S. K. Min, C. H. Choi, J. R. Lee, Y. J. Kim, E.-J. Bae, and C. I. Noh Follow-Up of Shelhigh Porcine Pulmonic Valve Conduits Ann. Thorac. Surg., December 1, 2007; 84(6): 2047 - 2050. [Abstract] [Full Text] [PDF] |
||||
![]() |
T. Ishizaka, R. G. Ohye, C. S. Goldberg, S. R. Ramsburg, T. Suzuki, E. J. Devaney, and E. L. Bove Premature failure of small-sized Shelhigh No-React porcine pulmonic valve conduit model NR-4000 Eur. J. Cardiothorac. Surg., May 1, 2003; 23(5): 715 - 718. [Abstract] [Full Text] [PDF] |
||||
![]() |
D. B. Doty and J. R. Doty Stentless Aortic Valve Replacement: Bioprostheses Card. Surg. Adult, January 1, 2003; 2(2003): 889 - 898. [Full Text] |
||||
![]() |
G. B. Luciani, F. Santini, S. Auriemma, L. Barozzi, P. Bertolini, and A. Mazzucco Long-term results after aortic valve replacement with the Biocor PSB stentless xenograft in the elderly Ann. Thorac. Surg., May 1, 2001; 71 (2007): S306 - S310. [Abstract] [Full Text] [PDF] |
||||
![]() |
K. Kirali, M. Guler, A. Tuncer, B. Daglar, G. Ipek, O. Isik, and C. Yakut Fifteen-year clinical experience with the Biocor porcine bioprostheses in the mitral position Ann. Thorac. Surg., March 1, 2001; 71(3): 811 - 815. [Abstract] [Full Text] [PDF] |
||||
![]() |
S. M. Marianeschi, G. M. Iacona, F. Seddio, R. F. Abella, C. Condoluci, A. Cipriani, F. S. Iorio, S. Gabbay, and C. F. Marcelletti Shelhigh No-React porcine pulmonic valve conduit: a new alternative to the homograft Ann. Thorac. Surg., February 1, 2001; 71(2): 619 - 623. [Abstract] [Full Text] [PDF] |
||||
![]() |
S. Milo Possible mechanism of calcification of the BioCor stentless mitral valve treated with the No-React formula J. Thorac. Cardiovasc. Surg., October 1, 1999; 118(4): 772 - 773. [Full Text] |
||||
![]() |
S. Milo, Z. Adler, Y. Bar-El, V. Kertsman, S. Sawaed, A. Lorber, and S. Reisner NO-REACT* ANTICALCIFICATION TISSUE TREATMENT RESULTS WITH STENTLESS HEART VALVES IN TWO ADOLESCENTS J. Thorac. Cardiovasc. Surg., June 1, 1999; 117(6): 1222 - 1223. [Full Text] [PDF] |
||||
| ||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||
| HOME | HELP | FEEDBACK | SUBSCRIPTIONS | ARCHIVE | SEARCH | TABLE OF CONTENTS |
| ANN THORAC SURG | ASIAN CARDIOVASC THORAC ANN | EUR J CARDIOTHORAC SURG |
| J THORAC CARDIOVASC SURG | ICVTS | ALL CTSNet JOURNALS |